Endre søk
RefereraExporteraLink to record
Permanent link

Direct link
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annet format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annet språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf
A thermodynamic study of silicon containing gas around a blast furnace raceway
KTH, Skolan för industriell teknik och management (ITM), Materialvetenskap, Tillämpad processmetallurgi.
KTH, Skolan för industriell teknik och management (ITM), Materialvetenskap, Tillämpad processmetallurgi.
KTH, Skolan för industriell teknik och management (ITM), Materialvetenskap, Tillämpad processmetallurgi.
2005 (engelsk)Inngår i: ISIJ International, ISSN 0915-1559, E-ISSN 1347-5460, Vol. 45, nr 5, s. 662-668Artikkel i tidsskrift (Fagfellevurdert) Published
Abstract [en]

The equilibrium conditions for silicon transfer from ash to the liquid metal phase via SiO gas have been discussed by several authors. However, no published calculations have been found using the most modern thermodynamic models available. Since there are major differences in the results of calculations using different thermodynamic models and the models are continuously being improved, new equilibrium calculations on SiO and SiS gas formation have been performed using the recently developed models. Different ingoing compositions of coke ash, coal powder ash and blast air were used in the calculations. The compositions chosen represent blast furnace no. 3 at SSAB in Lulea, Sweden. Temperature was found to be the major factor influencing the equilibrium silicon level in the gas phase. At low temperatures (below 1 600 degrees C the total gas pressure was also seen to influence the silicon content in the gas phase. The main reason for this is that below 1 600 degrees C, the amount of liquid slag at equilibrium increases with the total gas pressure. Liquid slag contains large amounts of silica that then can not be found in the gas phase. Higher carbon activity is usually expected to result in higher SiO gas levels in the blast furnace. The equilibrium calculations show that increased carbon activity increases the amount of silicon in the gas phase at temperatures up to about 1 600 degrees C, but that at higher temperatures SiC is formed that decreases the equilibrium silicon level in the gas phase.

sted, utgiver, år, opplag, sider
2005. Vol. 45, nr 5, s. 662-668
Emneord [en]
ironmaking, blast furnace chemistry, thermodynamics, calculation, slags, cast iron, gases, silicon compounds
HSV kategori
Identifikatorer
URN: urn:nbn:se:kth:diva-38229DOI: 10.2355/isijinternational.45.662ISI: 000229310700006Scopus ID: 2-s2.0-22544441892OAI: oai:DiVA.org:kth-38229DiVA, id: diva2:436316
Merknad

QC 20110823

Tilgjengelig fra: 2011-08-23 Laget: 2011-08-23 Sist oppdatert: 2017-12-08bibliografisk kontrollert

Open Access i DiVA

Fulltekst mangler i DiVA

Andre lenker

Forlagets fulltekstScopus

Søk i DiVA

Av forfatter/redaktør
Gustavsson, JoelAndersson, Margareta A.T.Jönsson, Pär
Av organisasjonen
I samme tidsskrift
ISIJ International

Søk utenfor DiVA

GoogleGoogle Scholar

doi
urn-nbn

Altmetric

doi
urn-nbn
Totalt: 71 treff
RefereraExporteraLink to record
Permanent link

Direct link
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annet format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annet språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf