Ändra sökning
RefereraExporteraLänk till posten
Permanent länk

Direktlänk
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annat format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annat språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf
Temperature, emission and lean blowoff limit of simulated gasified biomass in a premixed combustor
KTH, Skolan för industriell teknik och management (ITM), Energiteknik, Kraft- och värmeteknologi.
KTH, Skolan för industriell teknik och management (ITM), Energiteknik, Kraft- och värmeteknologi.
KTH, Skolan för industriell teknik och management (ITM), Energiteknik, Kraft- och värmeteknologi.
(Engelska)Ingår i: Applied Energy, ISSN 0306-2619, E-ISSN 1872-9118Artikel i tidskrift (Övrigt vetenskapligt) Submitted
Abstract [en]

Biomass can be converted to a gaseous fuel through gasification in order to be used in higher efficiency conversion. Combustion of gasified biomass gas (GBG) in gas turbines, for example, potentially reduces the CO2 emission compared to natural gas and diminishes the dependence of fossil fuels. However, the wide variety in the gas composition and its lower heating value will affect the subsequent combustion process with respect to emission levels and flame stability. In this study, premixed combustion of simulated GBG is investigated experimentally at atmospheric pressure and compared with pure CH4 (simulated natural gas). Combustion performance in terms of emission levels and blowoff is observed. The GBG fuel with noncombustible to combustible components ratio of 1.5 is tested in comparison with pure CH4 at fixed input thermal load. The GBG fuel consists of a mixture of CO/H2/CH4/CO2/N2and its proportion reassembles the mixture from air‐blown gasification. The high diluent content decreases the lower heating value (LHV) and increases the volumetric flow compared to CH4. As a result, lower combustion temperature and different flame region than CH4were found in the combustor. However, the GBG combustion still can be stabilized at lower temperature and leaner condition compared to CH4 while maintaining low CO and NOx emissions. As low as ~15 ppm and ~5ppm of CO and NOxemissions, respectively, could be achieved at an equivalence ratio equal to 0.5. It was found that at a combustion temperature below ~800oC, both CO and UHC start to rise from their stable and low concentration. At different input thermal loads, a shift in the optimum operating condition for the GBG combustion was found. No auto‐ignition or flashback events were found during the combustion of GBG in all experiment conditions tested. The results show the possibility to use both GBG and natural gas in one and the same combustor without compromising low emission levels.

Nyckelord [en]
gasified biomass gas; premixed, atmospheric combustion; CO, UHC and NOx emissions
Nationell ämneskategori
Energiteknik
Identifikatorer
URN: urn:nbn:se:kth:diva-120572OAI: oai:DiVA.org:kth-120572DiVA, id: diva2:615588
Anmärkning

QS 2013

Tillgänglig från: 2013-04-11 Skapad: 2013-04-11 Senast uppdaterad: 2017-12-06Bibliografiskt granskad
Ingår i avhandling
1. Combustion of gasified biomass:: Experimental investigation on laminar flame speed, lean blowoff limit and emission levels
Öppna denna publikation i ny flik eller fönster >>Combustion of gasified biomass:: Experimental investigation on laminar flame speed, lean blowoff limit and emission levels
2013 (Engelska)Doktorsavhandling, sammanläggning (Övrigt vetenskapligt)
Abstract [en]

Biomass is among the primary alternative energy sources that supplements the fossil fuels to meet today’s energy demand. Gasification is an efficient and environmental friendly technology for converting the energy content in the biomass into a combustible gas mixture, which can be used in various applications. The composition of this gas mixture varies greatly depending on the gasification agent, gasifier design and its operation parameters and can be classified as low and medium LHV gasified biomass. The wide range of possible gas composition between each of these classes and even within each class itself can be a challenge in the combustion for heat and/or power production. The difficulty is primarily associated with the range in the combustion properties that may affect the stability and the emission levels. Therefore, this thesis is intended to provide data of combustion properties for improving the operation or design of atmospheric combustion devices operated with such gas mixtures.

The first part of this thesis presents a series of experimental work on combustion of low LHV gasified biomass (a simulated gas mixture of CO/H2/CH4/CO2/N2) with variation in the content of H2O and tar compound (simulated by C6H6). The laminar flame speed, lean blowoff limit and emission levels of low LHV gasified biomass based on the premixed combustion concept are reported in paper I and III. The results show that the presence of H2O and C6H6 in gasified biomass can give positive effects on these combustion parameters (laminar flame speed, lean blowoff limit and emission levels), but also that there are limits for these effects. Addition of a low percentage of H2O in the gasified biomass resulted in almost constant laminar flame speed and combustion temperature of the gas mixture, while its NOx emission and blowoff temperature were decreased. The opposite condition was found when H2O content was further increased. The blowoff limit was shifted to richer fuel equivalence ratio as H2O increased. A temperature limit was observed where CO emission could be maintained at low concentration. With C6H6 addition, the laminar flame speed first decreased, achieved a minimum value, and then increased with further addition of C6H6. The combustion temperature and NOx emission were increased, CO emission was reduced, and blowoff occurs at slightly higher equivalence ratio and temperature when C6H6 content is increased. The comparison with natural gas (simulated by CH4) is also made as can be found in paper I and II. Lower laminar flame speed, combustion temperature, slightly higher CO emission, lower NOx emission and leaner blowoff limit were obtained for low LHV gas mixture in comparison to natural gas.

In the second part of the thesis, the focus is put on the combustion of a wide range of gasified biomass types, ranging from low to medium LHV gas mixture (paper IV). The correlation between laminar flame speed or lean blowoff limit and the composition of various gas mixtures was investigated (paper IV). It was found that H2 and content of diluents have higher influence on the laminar flame speed of the gas mixture compared to its CO and hydrocarbon contents. For lean blowoff limit, the diluents have the greatest impact followed by H2 and CO. The mathematical correlations derived from the study can be used to for models of these two combustion parameters for a wide range of gasified biomass fuel compositions.

Ort, förlag, år, upplaga, sidor
Stockholm: KTH Royal Institute of Technology, 2013. s. 81
Serie
TRITA-KRV, ISSN 1100-7990 ; 13:03
Nyckelord
biomass gasification; gasified biomass; laminar flame speed; blowoff; emissions
Nationell ämneskategori
Energiteknik
Identifikatorer
urn:nbn:se:kth:diva-120570 (URN)978-91-7501-710-5 (ISBN)
Disputation
2013-04-22, M3, Brinellvägen 64, KTH, Stockholm, 10:00 (Engelska)
Opponent
Handledare
Anmärkning

QC 20130411

Tillgänglig från: 2013-04-11 Skapad: 2013-04-11 Senast uppdaterad: 2014-01-16Bibliografiskt granskad

Open Access i DiVA

Fulltext saknas i DiVA

Sök vidare i DiVA

Av författaren/redaktören
Binti Munajat, Nur FarizanErlich, CatharinaFransson, Torsten H.
Av organisationen
Kraft- och värmeteknologi
I samma tidskrift
Applied Energy
Energiteknik

Sök vidare utanför DiVA

GoogleGoogle Scholar

urn-nbn

Altmetricpoäng

urn-nbn
Totalt: 287 träffar
RefereraExporteraLänk till posten
Permanent länk

Direktlänk
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annat format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annat språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf