Change search
ReferencesLink to record
Permanent link

Direct link
A simple technique for refrigerant mass measurement
KTH, School of Industrial Engineering and Management (ITM), Energy Technology, Applied Thermodynamics and Refrigeration.
2005 (English)In: Applied Thermal Engineering, ISSN 1359-4311, E-ISSN 1873-5606, Vol. 25, no 8-9, 1115-1125 p.Article in journal (Refereed) Published
Abstract [en]

A simple technique for refrigerant mass measurement is described and evaluated. First, quick-closing valves trap the refrigerant in the section under consideration. Then, the refrigerant is expanded into a tank, thus reaching a superheated state. Finally the mass is calculated by p-nu-T relationship. The technique was implemented on a domestic refrigerator and was computer automated (no need for manual intervention). Preliminary (1) data are reported of the charge distribution during an on-off cycle.

Place, publisher, year, edition, pages
2005. Vol. 25, no 8-9, 1115-1125 p.
Keyword [en]
charge inventory, void fraction, domestic refrigerator
URN: urn:nbn:se:kth:diva-14587DOI: 10.1016/j.applthermaleng.2004.09.0008ISI: 000227503300002ScopusID: 2-s2.0-13444274600OAI: diva2:332628
QC 20100525Available from: 2010-08-05 Created: 2010-08-05 Last updated: 2012-04-11Bibliographically approved
In thesis
1. Energy Efficiency Improvements in Household Refrigeration Cooling Systems
Open this publication in new window or tab >>Energy Efficiency Improvements in Household Refrigeration Cooling Systems
2012 (English)Doctoral thesis, comprehensive summary (Other academic)
Abstract [en]

This thesis is based on eight articles all related to the characteristics of the cooling system and plate evaporator of a household refrigerator. Through these articles, knowledge is provided that can be used to increase the operational efficiency in household refrigeration. Papers A, B and C focus on heat transfer and pressure drop in a commonly used free convection evaporator – the plate evaporator. Applicable correlations are suggested on how to estimate the air side heat transfer, the refrigerant side pressure drop and the refrigerant side heat transfer. Papers D, E and F hold a unique experimental study of the refrigerant charge distribution in the cooling system at transient and steady state conditions. From this cyclic losses are identified and estimated and ways to overcome them are suggested. In paper G the topic “charging and throttling” is investigated in an unparalleled experimental study based on more than 600 data points at different quantities of charge and expansions device capacities. It results in recommendations on how to optimize the capillary tube length and the quantity of refrigerant charge. Finally, Paper H holds a thermographic study of the overall cooling system operating at transient conditions. Overall, a potential to lower the energy use by as much as 25 % was identified in the refrigerator studied. About 10 % was found on the evaporator’s air side. 1-2 % was identified as losses related to the edge effect of the evaporator plate. About 8 % was estimated to be cyclic losses. About 5 % was found in cycle length optimization.  It is believed that most of these findings are of general interest for the whole field of household refrigeration even though the results come from one type of refrigerator. Suggestions of simple means to reduce the losses without increasing the unit price are provided within the thesis

Place, publisher, year, edition, pages
Stockholm: KTH Royal Institute of Technology, 2012. 115 p.
TRITA-REFR, ISSN 1102-0245 ; 12:02
Household refrigerator, Domestic refrigerator, Free convection, Plate evaporator, Heat transfer, Flow boiling, Isobutane, R600a, Pressure drop, Two-phase, Cooling system, Charge inventory, Cyclic losses, Thermography
National Category
Energy Engineering
urn:nbn:se:kth:diva-93061 (URN)978-91-7501-306-0 (ISBN)
Public defence
2012-04-27, F3, Lindstedtsvägen 26, Stockholm, 10:00 (English)

QC 20120411

Available from: 2012-04-11 Created: 2012-04-10 Last updated: 2014-02-11Bibliographically approved

Open Access in DiVA

No full text

Other links

Publisher's full textScopus

Search in DiVA

By author/editor
Björk, Erik T.
By organisation
Applied Thermodynamics and Refrigeration
In the same journal
Applied Thermal Engineering

Search outside of DiVA

GoogleGoogle Scholar
The number of downloads is the sum of all downloads of full texts. It may include eg previous versions that are now no longer available

Altmetric score

Total: 71 hits
ReferencesLink to record
Permanent link

Direct link