Change search
ReferencesLink to record
Permanent link

Direct link
Influence of shear on fibre orientation in the near wall region
KTH, Superseded Departments, Mechanics.
STFI-Packforsk.ORCID iD: 0000-0003-3737-0091
2004 (English)Article in journal (Other academic) Submitted
Place, publisher, year, edition, pages
National Category
Mechanical Engineering
URN: urn:nbn:se:kth:diva-25427OAI: diva2:358203
QS 20120313Available from: 2010-10-21 Created: 2010-10-21 Last updated: 2012-03-13Bibliographically approved
In thesis
1. Fluid mechanics of fibre suspensions related to papermaking
Open this publication in new window or tab >>Fluid mechanics of fibre suspensions related to papermaking
2005 (English)Doctoral thesis, comprehensive summary (Other scientific)
Abstract [en]

This thesis deals with fluid dynamic mechanisms related to papermaking, specif- ically: the initial dewatering mechanisms during roll-forming and fibre motion in sedimentation and in shear flow.

Pressure and wire position measurements have been conducted in a model resembling the forming zone and the measured pressure distributions are shown to have more complex patterns than the simple model p / T/R (where T is the wire tension and R is the roll radius). It is shown that an increase in wire tension has a similar effect as a decrease in flow-rate on the shape of the pressure distribution. In addition, it is shown that the drainage has a stabilizing effect on the dewatering pressure.

The flow around the forming roll has also been modelled with the assump- tion that the wire is impermeable. A non-linear equation for the position of the wire is derived that clearly shows that the Weber number, We, is an im- portant parameter. The equation is linearized around the trivial solution and has a standing wave solution with a specific wavelength that scales with the We-number.

Motion of non-Brownian fibre settling in a Newtonian fluid at a small but finite Reynolds number has been studied experimentally. Two different regimes of sedimentation were identified. For dilute suspensions, fibres gener- ally fall without flipping and may travel at velocities larger than that of an isolated particle. In the semi-dilute regime we found the settling process to be dominated by large-scale fluctuations. The velocity fluctuations scale with the suspension volume concentrationφ according toφ1/3, which is similar to the findings for settling spheres.

The influence of shear on fibre orientation in the near wall region was studied in cellulose acetate fibre suspensions. At low concentration and low aspect ratio fibres were observed to orient perpendicular to the streamwise direction (named rollers) in the near wall region whereas the orientation further into the suspension was unchanged. As the concentration and aspect ratio increased the fraction of rollers decreased.

Finally, an evaluation of a commercial Ultra Velocity Profiler unit in fibre suspensions are presented. The idea was to determine the velocity and characterise the turbulence from ultra sound echoes from particles in the fluid. However, the spatial and/or temporal resolution of the measurements did not permit turbulence characterisation. These limitations might be possible to overcome and some procedures are proposed and evaluated.

Place, publisher, year, edition, pages
Stockholm: KTH, 2005. x, 42 p.
Trita-MEK, ISSN 0348-467X ; 2005:1
Applied mechanics, applied fluid mechanics, fibre suspensions, roll-forming, sedimentation, shear flow, Teknisk mekanik
National Category
Mechanical Engineering
urn:nbn:se:kth:diva-100 (URN)
Public defence
2005-01-14, Kollegiesalen, Valhallavägen 79, Stockholm, 10:00
QC 20101021Available from: 2005-02-02 Created: 2005-02-02 Last updated: 2010-10-21Bibliographically approved

Open Access in DiVA

No full text

Search in DiVA

By author/editor
Holm, RichardSöderberg, L. Daniel
By organisation
Mechanical Engineering

Search outside of DiVA

GoogleGoogle Scholar
The number of downloads is the sum of all downloads of full texts. It may include eg previous versions that are now no longer available

Total: 36 hits
ReferencesLink to record
Permanent link

Direct link