Change search
ReferencesLink to record
Permanent link

Direct link
Enhanced biogas production by increasing organic load rate in mesophilic anaerobic digestion with sludge recirculation.
KTH, School of Architecture and the Built Environment (ABE), Land and Water Resources Engineering (moved 20130630), Water, Sewage and Waste technology.
2012 (English)Independent thesis Advanced level (degree of Master (Two Years)), 20 credits / 30 HE creditsStudent thesis
Abstract [en]

For enhancing anaerobic sludge digestion and biogas recovery, an increase in organic load rate (OLR) from 1.0 to 3.0kgVS/(m3·day) was imposed upon a new anaerobic digestion process combined with a sludge recirculation. The new setup requires a traditional mesophilic anaerobic digester coupled with a centrifuge for maintaining relatively high solid content within the digester.

The hypothesis of this study was that increasing continuously OLR from 1.0 to 3.0kgVS/(m3·day) in a pilot-scale anaerobic digester with recycled sludge would not badly influence the digester stability, based on which biogas production would be enhanced. To test this hypothesis, a continuous 73-day study with laboratory experiment was conducted. Due to scarcity of original feeding sludge and its deteriorating quality, OLR had to be increased relied on introduction of extra sludge followed by measurement of total solid (TS) and volatile solid (VS) contents in both feeding sludge and digester sludge, for calculating OLR and examining its variations. To assess the relationship between biogas production and OLR, a measurement of gas yield and methane content was a necessity, performed by applying a biogas flow meter and MSA AUER EX-METER II (P). Moreover, temperature, pH value, volatile fatty acid (VFA) and alkalinity must be tested frequently, for the purpose of preventing system failure.

The results demonstrate that the digester succeeded in withstanding an OLR up to 3.15kgVS/(m3·day). Furthermore, an enhancement in biogas yield and methane content were observed after increasing the OLR by introducing extra sludge. Biogas production measurement performed during this study indicated that biogas yield was enhanced by 73%, with a maximum production of 14.5m3/day, when OLR was increased from 2.05 to 3.15kgVS/(m3·day). However, methane content was merely promoted by 10.5%, to the highest value of 63%, with the same increase in OLR. Specific gas production (SGP), as another means of evaluating the relationship between biogas production and OLR, was observed to be 0.65Nm3/kg VSin averagely.

Place, publisher, year, edition, pages
2012. , 20 p.
, TRITA-LWR Degree Project, ISSN 1651-064X ; LWR-EX-12-17
Keyword [en]
biogas, methane, anaerobic digestion, mesophilic condition, organic load rate, specific gas production, total solid and volatile solid
National Category
Water Engineering
URN: urn:nbn:se:kth:diva-99354OAI: diva2:541977
Educational program
Degree of Master - Water System Technology
Available from: 2012-07-26 Created: 2012-07-26 Last updated: 2012-07-26Bibliographically approved

Open Access in DiVA

fulltext(1370 kB)1257 downloads
File information
File name FULLTEXT01.pdfFile size 1370 kBChecksum SHA-512
Type fulltextMimetype application/pdf

By organisation
Water, Sewage and Waste technology
Water Engineering

Search outside of DiVA

GoogleGoogle Scholar
Total: 1257 downloads
The number of downloads is the sum of all downloads of full texts. It may include eg previous versions that are now no longer available

Total: 167 hits
ReferencesLink to record
Permanent link

Direct link